See a great deal of new and old Toyota car and truck content at the rest of Toyoland!

carb. problems
Read 3484 times
* December 13, 2006, 04:25:20 AM
:S Having problems with carb. on 1990 Toyota pickup. 22R 4 speed manuel, floods until it reaches operating temperature then it runs fine. mileage is suffering. have cleaned carb and rebuilt, same problem. Any suggestions?

Logged


* December 14, 2006, 03:42:50 AM
#1
X(carb. is still flooding. took it apart again. anyone toyota mechanics in the room?

Logged


* December 14, 2006, 05:27:26 PM
#2
What do you mean by flooding - is gas pouring out of the carb (shut engine off and see if the gas still flows out), or is the engine just bogging down - engine hesistation?

If this does this when only cold and improves when hot - may not be a carb issue.  Could be a problem with the choke, bad fuel pressure regulator, clogged EVAP system (charcoal canister), clogged vent, etc.

Also what setup is this on your 22R - is it the single or dual 45 DCOE carbs. I assume the rebuild kit your changed the accelerator pumps and made sure to soak it enough to make sure everything was clean - all o-rings in place, needles are clean, new carb gasket, all vacuum lines in place, etc.

Logged


 

Site created and maintained by David Zatz. He has written four car books.